Share:


Mechanical performance of composite retaining and protection structure for super large and deep foundation excavations

    Zhen Cui Affiliation
    ; Qimin Li Affiliation
    ; Jian Wang Affiliation

Abstract

The reliable retaining methods and a good stress system are the key to the success of super large and deep excavation engineering. In this paper, the deepest foundation pit in Hainan province is taken as an example. The method of mutual verification between in-situ monitoring and numerical simulation is adopted. The mechanical performance of composite retaining structure composed of reinforced concrete cast-in-situ soldier pile wall, diaphragm wall and prestressed anchor cable are studied. The interaction between the reinforced concrete cast-in-situ pile retaining structure at the upper part and the diaphragm wall retaining structure at the lower part is revealed, and the variation of internal forces of the diaphragm wall retaining structure in the time and space is demonstrated. And then the influence of insertion ratio and rigidity on the mechanical properties of diaphragm wall is discussed. Research shows, the range of interaction between the upper and lower retaining structures is limited. During the excavation process, the maximum bending moment of the diaphragm wall is always near the excavation surface, and the curvature of the bending moment curve decreases gradually with the increase of excavation depth and axial tension of anchor. When the insertion ratio of diaphragm wall increases, the maximum bending moment moves upward. With the rigidity of the diaphragm wall increases moderately, the bending moment of the retaining structure increases, but the lateral displacement decreases. The research results can provide theoretical basis and practical experience for the composite retaining structure design of super large and deep foundation excavations.

Keyword : super deep excavations, composite retaining structure, on-site monitoring, numerical simulation, mechanical effect, time effect, rigidity effect

How to Cite
Cui, Z., Li, Q., & Wang, J. (2019). Mechanical performance of composite retaining and protection structure for super large and deep foundation excavations. Journal of Civil Engineering and Management, 25(5), 431-440. https://doi.org/10.3846/jcem.2019.9873
Published in Issue
May 2, 2019
Abstract Views
40
PDF Downloads
28
Creative Commons License

This work is licensed under a Creative Commons Attribution 4.0 International License.

References

Bryson, L. S., Zapata-Medina, D. G. (2012). Method for estimating system rigidity for excavation support walls. Journal of Geotechnical and Geoenvironmental Engineering, 138(9), 1104-1115. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000683

Chen, J., Yang, J., Zhang, X., Wang, S., & Ou, X. (2017). Field measurements and design optimization of diaphragm walls. Geotechnical Testing Journal, 40(1), 84-91. https://doi.org/10.1520/GTJ20160022

Cheng, X. S., Zheng, G., Diao, Y., Huang, T. M., Deng, C. H., Lei, Y. W., & Zhou, H. Z. (2017). Study of the progressive collapse mechanism of excavations retained by cantilever contiguous piles. Engineering Failure Analysis, 71, 72-89. https://doi.org/10.1016/j.engfailanal.2016.06.011

Faheem, H., Cai, F., & Ugai, K. (2004). Three-dimensional base stability of rectangular excavations in soft soils using FEM. Computers and Geotechnics, 31(2), 67-74. https://doi.org/10.1016/j.compgeo.2004.02.005

Hyun, S. J., Hyung, J. S., & Yeol, S. J. (2011). A study for safety management on ground excavation by analysis of accident events. Journal of The Korea Institute for Structural Maintenance and Inspection, 15(6), 175-183. https://doi.org/10.11112/jksmi.2011.15.6.175

Li, X. Z, Zhang, P. X, He, Z. C, Huang, Z., Cheng, M. L., & Guo, L. (2017). Identification of geological structure which induced heavy water and mud inrush in tunnel excavation: A case study on Lingjiao tunnel. Tunnelling and Underground Space Technology, 69, 203-208. http://dx.doi.org/10.1016/j.trust.2017.06.014

Lin, P., Liu, H., & Zhou, W. (2015). Experimental study on failure behaviour of deep tunnels under high in-situ stresses. Tunnelling and Underground Space Technology, 46, 28-45. https://doi.org/10.1016/j.tust.2014.10.009

Liyanapathirana, D. S., & Nishanthan, R. (2016). Influence of deep excavation induced ground movements on adjacent piles. Tunnelling and Underground Space Technology, 52, 168-181. https://doi.org/10.1016/j.tust.2015.11.019

Ninic, J., Stascheit, J., & Meschke, G. (2014). Beam-solid contact formulation for finite element analysis of pile-soil interaction with arbitrary discretization. International Journal for Numerical and Analytical Methods in Geomechanics, 38(14), 1453-1476. https://doi.org/10.1002/nag.2262

Ooi, P. S. K., & Ramsey, T. L. (2003). Curvature and bending moments from inclinometer data. International Journal of Geomechanics, 3(1), 64-74. https://doi.org/10.1061/(ASCE)1532-3641(2003)3:1(64)

Szepesházi, A., Mahler, A., & Móczár, B. (2016). Three dimensional finite element analysis of deep excavations’ concave corners. Periodica Polytechnica Civil Engineering, 60(3), 371-378. https://doi.org/10.3311/PPci.8608

Tan, Y., Zhu, H., Peng, F., Karlsrud, K., & Wei, B. (2017). Characterization of semi-top-down excavation for subway station in Shanghai soft ground. Tunnelling and Underground Space Technology, 68, 244-261. https://doi.org/10.1016/j.tust.2017.05.028

Wang, J., Li, Q., Yang, C., Huang, Y., & Zhou, C. (2018). A simple model for elastic-plastic contact of granular geomaterials. Advances in Materials Science and Engineering, Article ID 6783791. https://doi.org/10.1155/2018/6783791

Wang, J., Li, Q., Yang, C., & Zhou, C. (2018). Repeated loading model for elastic-plastic contact of geomaterial. Advances in Mechanical Engineering, 10(7), 1-15. https://doi.org/10.1177/1687814018788778

Yang, X. H., Zhu, Y. P., & Guo, N. 2014. Internal force test research on pile-anchor retaining structure of metro station deep foundation. Rock and Soil Mechanics, 34(2), 185-197.

Zeng, F. Y., Zhang, Z. J., Wang, J. H., & Li, M. G. (2018). Observed performance of two adjacent and concurrently excavated deep foundation pits in soft clay. Journal of Performance of Constructed Facilities, 32(4). https://doi.org/10.1061/(ASCE)CF.1943-5509.0001184

Zhang, Z. C., Chen, Y. M., & Liu, H. L. (2016). Numerical investigation on the impact resistance of road barriers of Micropile-MSE Wall for subgrade. Computers and Geotechnics, 82, 249-265. https://doi.org/10.1016/j.compgeo.2016.10.004

Zhao, L., & You, G. (2018). Stability study on the northern batter of MBC Open Pit using Plaxis 3D. Arabian Journal of Geosciences, 11(6). https://doi.org/10.1007/s12517-018-3454-1

Zhao, W., Han, J. Y., & Chen, Y. (2018). A numerical study on the influence of anchorage failure for a deep excavation retained by anchored pile walls. Advances in Mechanical Engineering, 10(2). https://doi.org/10.1177/1687814018756775